Turbocharged engine maintenance guide

  1, the oil must use good
         In Bora, Passat, for example, damage to the turbocharger oil seal damage is usually with the intake manifold between the leading large-scale burning oil, but found from our survey, Mini Cooper turbo damaged seal of a large part because the owners no time to change the oil, or the use of inferior oil, resulting in a floating turbine main axis of rotation is not normal lubrication and cooling, thereby causing damage to the oil seal leakage at high temperatures.
         Therefore, we recommend turbocharged engine should choose high temperature anti-oxidation good quality oil, and also pay attention to the proper shorten oil change intervals.
         2 to keep the turbo clean
         Turbocharger with the gap between the shaft and the sleeve is small, so if the oil used oil filter is not clean or not clean because of impurities into the lead, as it will cause excessive wear on the turbocharger. In addition, if inhaled air contains a lot of impurities, these dust particles enters the turbocharger impeller speed operation,T3 Turbo it will make the dust particles hit turbocharger impellers, turbine operation resulting instability, bushings and seals wear, so turbo models pay special attention to the timely replacement of oil filter and air filter, clean the turbine.
         3, cold start to slow, hot car should idle for a while and then turn off
         By understanding more than we know now belong to a high-speed turbine moving parts, so they need real-time protection of lubricating oil, and at the beginning of the cold start, the engine oil temperature is usually relatively low, relatively thick, poor lubrication, and let it heat up to normal operating temperature is required to have a process and time, within a few minutes if you are forced in this turbine at full load state work, then the turbine will increase the wear and shorten the life of the turbine.
         Therefore, the correct use of the method is that the first few minutes you are in the car idle for a few minutes should be, and so the oil into the best condition, and then let the engine throttle high speed operation, especially after the northern winter, the cold start certain pay attention to let the car hot walk, 4 cylinder 2.0 turbo it comfortable you comfortable. And about parking it is very easy to be ignored by the majority of the owners, because the temperature of the turbine work up very high, so you'd better parking spot after idling for a while and then off the car, then the engine oil and cooling system also in the work, which can reduce the temperature of the turbine down a little bit, to note that after the car off due to inertia caused by the turbine will continue to operate, oil lubrication still required at this time, if you turn off the engine suddenly, then the entire engine system is no longer working, the cooling system of the turbine and lubricating oil supply will come to an end, can only rely on natural cooling, and this will lead to a sharp drop in the life of the turbine.